engine cold, undo drain plug at bottom of rad remove top and bottom hoses and disconnect electric fan plug, bolts at both sides of rad undo and remove rad undo electic fan housing and fan and fit to new rad, refit to car connect electic fan fill with water and anti freeze let engine run with the expanion chamber cap of ( thats where you fill with water) wait till the water gets hot in chamber this will stop any air blocks in system refit cap .recheck levels for first 2,3 days after job good luckHow easy is it to change a radiator on a Ford Escort?fairly simple. it is just 2 bolts and 1 or 2 lines most. it should take like 35 minutes at most.How easy is it to change a radiator on a Ford Escort?Most car radiators are relatively easy to change because they're located right out in front of the engine where you can get to them. However, it wouldn't hurt to first read the replacement procedure in a repair manual you can buy at the auto store or read for free in the library. Also check http://www.autozone.com for instructions on the website. Be careful not to pierce the new radiator fin tubes when replacing it. The transmission oil coolant lines may be a little rusty, so apply penetrating oil and gradually loosen them with a proper brake line type wrench which fits the hex nut better and won't round the nut off. You should replace the upper and lower radiator hoses and use worm drive clamps.How easy is it to change a radiator on a Ford Escort?A very easy job first release all the hoses udo the holding small bolts pull out, put in new rad in reverseHow easy is it to change a radiator on a Ford Escort?Don't forget when you drain the radiator to put your heater on hot. If you don't you will get an air lock in the heating system which can sometimes be difficult to put right again.How easy is it to change a radiator on a Ford Escort?very easyHow easy is it to change a radiator on a Ford Escort?Very easy, take you about 20 mins, just make sure the engine is cold as you dont want to get splattered in hot anti-freeze.
Its a straight forward job.
